Author Topic: '71 A65 lightning running rough  (Read 229 times)

0 Members and 1 Guest are viewing this topic.

CROFTY1984

  • Star
  • *
  • Posts: 42
    • View Profile
'71 A65 lightning running rough
« on: 05 March, 2018, 20:07:52 »
Hello all,
Following my previous posts, the A65 is starting pretty well, 3-4 kicks regardless of the weather :)
However it's running pretty badly on light throttle openings. I ultrasonically cleaned the carbs, took it out for a test run and thought I'd cured it, then after a mile or two the stutter came back. :(

Before the carb rebuild the right plug was a bit sooty so I'm going to try leaning out the idle mixture on that carb. It starts and runs well when accelerating but at a cruise at less than 1/4 throttle it just feels like a cylinder is missing a beat every few seconds.
Any other ideas about what to look at?
Thanks, Dan

JulianS

  • Empire Star
  • *****
  • Posts: 941
  • A10
    • View Profile
Re: '71 A65 lightning running rough
« Reply #1 on: 05 March, 2018, 22:35:34 »
Have you checked the Amal tuning guide or the workshop manual carb section, both give info on tuning and synchronising twin carbs.

http://amalcarb.co.uk/downloadfiles/amal/Mk1_Hints_and_Tips.pdf

Editor

  • Royal Star
  • ***
  • Posts: 171
    • View Profile
Re: '71 A65 lightning running rough
« Reply #2 on: 06 March, 2018, 11:41:16 »
Sounds like a weak mixture on one of the carbs on Pilot stage (first 1/8) of throttle). As you say it runs well whilst accelerating which singles out the pilot stage being the problem.
Despite ultrasonic cleaning, I would remove the offending carb and check the pilot bypass (the two small holes in the bottom of the choke bore, either side of the front of the slide, by squirting carb cleaner down one side and seeing if it comes out of the other. if it does, poke some copper stranded cable down them. I had to do this on my Thunderbolt a couple of years ago and it worked a treat.