Show Posts

This section allows you to view all posts made by this member. Note that you can only see posts made in areas you currently have access to.


Topics - TIGER

Pages: [1]
1
Singles / Trial run
« on: 12 July, 2017, 18:59:42 »
Just completed a few miles on the C15.
Running quite well.
Starts easy from cold BUT not when hot ?
Backfires on overrun.
Comments welcome
Regards
           Tim

2
Singles / C15 side stand
« on: 11 July, 2017, 16:53:44 »
Finally got a side stand only to find the fulcrum pin is too large to fit the lug.
I suspect pin is hardened.
Anyone had a similar problem
Regards
           Tim

3
Singles / C15 Speedo
« on: 10 July, 2017, 09:12:51 »
Finally got a speedometer.
Would anyone recommend lubrication for the cable.
Also speedo end of cable drive seems too long.
Not sure if different at each end.
Cable was previously fixed so may have take off tank etc.
Just about to fit 180 main jet for road trail.
Booking MOT this week
Updates later.
Regards
           Tim

4
Singles / C15 Forks
« on: 30 June, 2017, 08:18:10 »
After a few short test runs my forks are leaking badly.
So no chance of an MOT yet.
Have removed forks but seals look new but not a tight fit on stanchions.
In haste ordered 4 seals from Burton bikes but not sure if these will seal.
Stanchions look good no sign of ware.
Could anyone provide the diameter of stanchions please.
OR ANY OTHER HELP
Summer riding time is going fast !
Regards
            Tim

5
Singles / C15 rebuild
« on: 08 June, 2017, 11:42:14 »
As some of you know I have just finished a rebuild.
Just noticed the carb. Is 375/4
Engine is coded SS80
Information from Julian stated should be 376
Can I achieve reasonable running with the 375 or not
Not interested in top performance just a reliable run about.
Any advise much appreciated as usual
Regards
           Tim

6
The Star and Garter / C15 chain guard
« on: 02 June, 2017, 20:56:01 »
Hi people
             Me again with more woes.
             DVLA INSPECTOR HAPPY.
             Need a chain guard I have one which is close.
             Can anyone help with a detailed diagram ?
Regards
           Tim

7
The Star and Garter / Cardurettor sealing
« on: 12 May, 2017, 12:14:17 »
Hello people
                  Update on the C15
                  Solved the seat problem mainly due to help from Julian. (Thanks again)
                  Some fettling still to do.
Carb. Is leaking from float chamber cover dispite new gasket and Loctite cement.
Can anyone recommend a suitable cement ?
Regards
           Tim

8
The Star and Garter / HELP C15 seat
« on: 04 May, 2017, 21:43:09 »
Hi people not a happy chapy.
 Cannot get the seat to look correct.
Bike been on the bench for months when on the floor seat is impossible to get in line !
I may have the wrong seat.
Would a Bantam seat cause this problem.
Help and advise much appreciated.
NB WHEELS LINE UP WELL.
Fed up
         Tim

9
Singles / Ameter
« on: 03 May, 2017, 07:06:11 »
In all the previous excitement forgot to ask.
Ameter showing discharge.
Can it be wired wrongly?
Regards
          Tim

10
Singles / Ammeter wiring
« on: 03 May, 2017, 06:58:55 »
Hello folks
Update on my C15
Some of you may remember the progress of this rebuild.
Late last night managed to lower the bike to the floor it had been on the bench for months
so I wanted to run the engine again.
This is the first time complete with proper petrol tank.
Bike is all together apart from chain guard.
After several Kicks not even a single fire, thought about wet dumping etc.
Then noticed the fuse on the bench from earth connection (idiot)
Started first kick
Lots of fettling to do clutch, leek on carb., tappets.
Still waiting to be informed of date for DVLA INPECTOR.
There is positive hope of return to the road
Regard
         Tim

11
The Star and Garter / DVLA registration
« on: 02 May, 2017, 06:58:14 »
Hello People
Waiting for a DVLA oppionted rep. To inspect my C15.
This is apparently required before tax.
Anyone know what is involved in the inspection ?
NB I still have chain guard and seat to sort out !
Regards
            Tim

12
The Star and Garter / Regards to members
« on: 29 April, 2017, 10:32:49 »
I am nearing completion (if you ever do).
Many thanks to all the great advice.
As some of you will remember I am building a C15, it was mainly complete
But mostly in parts.
I have received lots of help from Arther,Julian and others.
Also noted no posts from Arther does anyone know now he is?
Regards
           Tim

13
Singles / C15 rear light
« on: 18 April, 2017, 22:56:30 »
I am experiencing difficulty fitting a bulb to the rear light.
As you know this is the stop and tail type I am on 6 volt, although I am using an offset bulb
in a similar type holder the pins do not align.
I thought the fitting may be different for 6 volt ? So tryed. a 12 volt bulb same no fit ?
Some of you may remember this bike came in boxes so not the original light.
Sorry to witter on but are 6volt and 12volt bulbs the same type of pins.
Thanks in anticipation.
Regards
          Tim

14
Singles / C15 lighting switch
« on: 17 April, 2017, 23:06:25 »
Just completed rewire.
I think the switch is not making contact.
Can these be opened up for repair ??
Otherwise more expense.
Too far to turn back now.
Regards
         Tim

Pages: [1]